volvo b18ft conversion help!?? for those who've done one!!

[dodgeram2500]

New poster! (less than 10 posts)

i'm in the middle of doing the volvo conversion.. can anyone help with a couple of plugs and wires .. i simply cant remember where they were unplugged from!! for some reason i didnt label them as i did all the others!

this multiplug near alternator



and one the same near inlet



and one eyelet in the middle... does this go to live or earth!?

[dodgeram2500]

New poster! (less than 10 posts)

i've figured out where all these wires go... one is for reverse switch the other is a live for fuel pump relays. the one near alternator seems to serve no purpose..

however i still cant get it to run.. i've connected thick grey wire to live. red/grey to fuel pump etc.

if i put a little petrol in the inlet it fires right up..

is there anyway of testing the injectors? also the fuel pump wont come on unless i put an earth on the bottom of one of the relays...

anyone ?? i'm going out of my mind here!!

[dave r5]

check yr tdc lead, the fuell pump wont fire untill it see's a signal

also check your engine earths


if no luck i have a loom or sale

[dodgeram2500]

New poster! (less than 10 posts)

the bloody thing started first time this morning!! ran it for a while ... fine... went back to it half an hour later and it wouldnt go again.. so i'm thinking earth's or earth problem now.. which is the tdc lead? do you mean crank sensor?

[dave r5]

yeah crank sencor

disconect the ecus for a an hour then try

coil paks are crap

have u checked for water in the bores

shody conection in wireing

[dodgeram2500]

New poster! (less than 10 posts)

i've ordered a crank sensor and cleaned all the earths up.. it started today. got it warm.. all seemed fine.. started it a few times... no problem... left it for an hour or so.. nothing... the petrol i used in my makeshift fuel tank is rather old... so that may not help... i've not checked for water but it doesnt steam when running... once i've got the fuel pump plumbed in properly and a new fuel filter i think it'll be ok...