dci HP pump swap info

[markey b]

hopefully someone on here can shed some light onto my question :)

I had a DCI 65 (2002) already remapped, front mount ready to go on etc..

basically my HP pump is dying a death, so need a new one.. will one from a DCI 80 physically fit and work, obviously i'll get it remapped to suit after.

also heard citroen C4 injector nozzles are good, but any idea what engine, eg. 2.0 hdi 90/110 or 1.6 hdi 90/110 etc etc

fannnnnnnnnnks :smokin:

[Tutuur]

Since i own a dci 100 i've been looking into this too.
The pump is exactly the same.

What's the fault? Mine intermittently gives out a "fuel pressure too low" warning.

Regarding the nozzles, 1.6hdi nozzles suppose to fit on 1.5dci injector and supposely flow more but i haven't got any confirmation of someone...

What intercooler do you have?

[Sparkie]

http://www.renaultforums.co.uk/showthread.php?t=115647&page=3

may have some info in this thread.... :)

[Slammed 66]

This has got my attention.

I'm going to keep the standard intercooler on my dci 80 but I'd be very interested in the nozzle changes and remap.

Don't forget to keep this updated markey :agree:

[markey b]

Did a leak off test and it was a dead injector, replaced and all is now good.

[Tutuur]

What where the symptons mate?

Mine occasionally throws a light too

[markey b]

I had really poor starting, leak off test showed 1x injector ****ed, and 2 not great

[Tutuur]

Hhmm have to check mine sometime soon too. Not really bad starting but it takes a few seconds. I sometimes get a coil light when i take of from the lights, car than judders and after a few secs goes again...